Schenectady International Incorporated - Congress Street
|EPA Identification Number:||NYD002070100|
|Facility Location:||1302 Congress Street, Schenectady, New York|
|Facility Contact Name:||Jim Witte, (518) 347-4308|
|EPA Contact Name:||Samuel Ezekwo, (212)637-4168, firstname.lastname@example.org|
|New York State Department of Environmental Conservation (NYSDEC) Case Manager:||Howard Brezner, (518) 357-2045, email@example.com|
|Last Updated:||April 2009|
|Environmental Indicator Status:||Human Exposures Under Control [PDF 4.53 MB, 15 pp] has been verified.
Groundwater Contamination Under Control [PDF 2.64 MB, 12 pp] has been verified.
The Schenectady International, Inc. - Congress Street facility encompasses approximately 8 acres within the City of Schenectady, Schenectady County, New York. Adjacent land uses include light industrial to the south and west; commercial facilities to the east and northwest; and residential areas to the north and northeast. The facility is situated on the side of a valley which slopes down to Cowhorn Creek. An active rail line is located between the facility and the Creek. The facility has operated at this location since 1910, manufacturing primarily industrial coatings. Manufacturing operations ceased at the facility in 1998. However, the administrative offices are still used by Schenectady International.
Site Regulatory Responsibility and Legal Instrument
Order on Consent issued September 13, 1993.
The facility was an interim status facility in the Resource Conservation and Recovery Act (RCRA) program but is being cleaned up under the New York State Inactive Hazardous Waste Site (Superfund) Program.
Potential Threats and Contaminants
The primary hazardous wastes generated at this facility are from chemical manufacturing operations. As a result of past operations at the facility, soil, surface water, sediment and groundwater contamination has occurred. The primary contaminants are: volatile organic compounds (VOCs) which include toluene, benzenes and xylenes and; semi-volatile compounds (SVOCs) which include phenols and polyaromatic hydrocarbons. Both aqueous (dissolved phase) and non-aqueous (free-phase) contamination has been detected. There is also contaminated soil at a small hill leading into a stream just outside the fence line, but still on the facility's property.
Cleanup Approach and Progress
The Remedial Investigation and Feasibility Study were completed in February 1997. In the interim, measures consisting of free phase floating material collection were implemented at the facility for source control. A Record of Decision (ROD) was issued in March 1998 to address the off-site contamination.
Under the ROD for off-site contamination, a Remedial Action Work Plan was submitted to implement the following components:
- a groundwater collection and treatment system;
- free phase floating material collection; and
- installation of a clay liner and erosion control to prevent off-site surface water contamination.
The Work Plan was approved in September 1997. Construction of the final remedy to address the groundwater contamination has been completed. A collection trench has been installed at the facility boundary and the contaminated water is pumped to a wastewater treatment plant where it is treated and released under a New York State Pollution Discharge Elimination System permit. Contamination in the small hill is degrading to nontoxic substances under natural ground conditions, so no intervention is necessary.
Remedial Action Phase 1
The Cowhorn Creek has been protected from groundwater contamination since 2001 with the installation of groundwater extraction wells along the perimeter of the site. Daily scrutiny of the groundwater extraction system has resulted in improvements and 99.5% operation since the beginning of 2008.
Remedial Investigation Phase 2
With the completion of the Pilot Study, the facility is now ready to start the cleanup. A supplemental remedial investigation was completed in 2007 and soil excavation and/or in situ remediation begun in 2008.
Copies of supporting technical documents and correspondence cited in this site fact sheet are available for public review at:
NYSDEC - Region 4 Office
1150 North Westscott Road
Schenectady, New York 12306
Attn: Mr. Howard Brezner
Telephone: (518) 357-2045
The New York State Department of Environmental Conservation (NYSDEC) makes its public records available for a review under the Freedom of Information Law (FOIL).