Hazardous Waste Cleanup: Exide Technologies in Reading, Pennsylvania
On this page:
- Cleanup Status
- Site Description
- Contaminants at this Facility
- Institutional/Engineer Controls
- Land Reuse
- Site Responsibility
For many years Exide operated a lead smelter and recycled lead batteries. As a result of 35 years of lead smelter operation prior to the installation of air pollution controls and the advent of the Clean Air Act of 1970, Exide contributed to lead emissions and releases that impacted the soils in the surrounding community and the conditions at the site. Presently, most of its operations at the facility has shut down except for the plastic recycling business.
The Resource Conservation and Recovery Act (RCRA) Corrective Action investigation and remediation at the Exide facility is twofold. It consists of the offsite soil investigation and cleanups and the multimedia onsite investigation to assess the impacts of Exide's past operations.
Offsite Soil Investigation and Cleanups:
Offsite Soil Sampling
In August 2000, the United States Environmental Protection Agency (EPA) issued an Administrative Order on Consent (AOC) to Exide to investigate the extent of lead contamination in soil in the community and to clean up properties that were adversely impacted by the lead emissions. In 2001 and 2002, Exide sampled approximately 600 properties, which equate to approximately 12,500 soil samples collected in Laureldale Borough and Muhlenberg Township.
Site-Specific Risk Assessment
In the summer of 2002, Exide initiated a site-specific risk assessment to determine a soil lead level that is protective for the community. The risk assessment evaluated lead exposure risks from various sources such as tap water, air, lead paint, soil, dust, and food. The risk assessment consisted of an environmental sampling of residences and a community blood lead study. The risk assessment targeted residences with children seven years old and younger, who are considered most susceptible to lead exposures. In 2007, EPA approved the site-specific risk assessment and determined a protective soil lead level of 650 parts per million (ppm) for residential properties. The applied cleanup level of 650 ppm ensures long term protection of the residents and the environment in Laureldale Borough and Muhlenberg Township.
Residential Soil Cleanups
Residential properties with soil lead levels of 650 ppm and less do not pose a health risk and did not require soil cleanup. In 2008 and 2009, residential properties that contained soil lead levels greater than 650 ppm were cleaned up. The cleanups consisted of soil excavation, backfilling with clean soil and restoring the property to its original condition. Exide and its contactors worked with the property owners to insure that the cleanups met the owners’ satisfaction. Exide cleaned up a total of 220 properties. The residential cleanups were completed in the Fall of 2009.
Remaining Offsite Investigation and Cleanup
Three offsite properties and 10 undeveloped parcels (zoned residential) are either ongoing or will require additional evaluation. These properties consist of the Sacred Heart Convent, the Rosedale Camp Ground and the Gethsemane Cemetery. Exide commenced the soil cleanup of the Convent property in November 2017. The cleanup is expected to be completed by the Summer 2018. Because of the change in use of the camp ground Exide is re-evaluating the risk assessment. Contingent on the risk assessment the camp ground may or may not require remediation. The undeveloped land and the cemetery will be formally addressed when development plans for these properties are prepared.
Bernhart Park Cleanup
Bernhart Park is a 37.6-acre community park located within a quarter mile of the Exide facility. Historic operations at the facility contributed to lead concentrations in soil, surface water, and sediment at the park. Exide worked extensively with the EPA, the Pennsylvania Department of Environmental Protection (PADEP) and the City of Reading to evaluate the potential lead exposure risks to park visitors and to develop a cleanup workplan to address those risks. The park was cleaned up and reopened in 2010.
Onsite Investigation and Cleanups:
Under the EPA Corrective Action and Waste Minimization Permit, Exide is conducting a RCRA Facility Investigation (RFI) to determine the nature and extent of potential releases of hazardous wastes or hazardous constituents from regulated units, solid waste management units, and other source areas at the facility. The media of concern consists of groundwater, sediment and soils. The RCRA Facility Investigation (RFI) Report is expected to be completed this Spring. Subsequently, Exide will submit the Corrective Measures Study (CMS) that outlines the proposed remedies. EPA expects to issue a Final Decision that will determine the appropriate remedies to address any environmental impacts onsite at the facility in 2019.
Interactive Map of Exide Technologies in Reading, Pennsylvania
View larger map
The Exide Technologies (Exide) facility is located in Laureldale Borough and Muhlenberg Township, just northeast of Reading, Pennsylvania and occupies approximately 50 acres. The facility began operation in the mid-1930s under the ownership of the Bower's Battery Company. In 1960 the name was changed to the General Battery and Ceramic Corporation and was changed again in 1969 to General Battery Corporation. In 1987, General Battery Corporation was acquired as a wholly owned subsidiary of Exide Corporation. Today the facility is owned and operated by Exide Technologies (Exide). Presently, most of the operations at the facility is shut down except for the plastic recycling.
The major contaminants and risks are elevated levels of lead and specific heavy metals associated with Exide's past operations in soil, sediment and groundwater.
The primary tool used by EPA to estimate risk from soil contaminated with lead is called the Integrated Exposure Uptake Biokinetic (IEUBK) model. This model is used to estimate blood lead concentrations for children within a study area that are exposed to lead from multiple sources. In the Exide investigation, this exposure would include the lead in the soil due to smelter emissions. A blood lead study concluded that the overall blood lead levels for children in the area are safely below the CDC standard. In fact, the average blood lead levels in the Exide study area were nearly identical to the national average of 2.0 ug/dL.
The need for Institutional Controls is yet to be determined.
The facility is unused except for plastic recycling activities.
RCRA Corrective Action activities at this facility have been conducted under the direction of EPA Region 3 with assistance from the PADEP.