Sid Richardson Carbon and Energy Company Clean Air Act Settlement
(Washington, D.C. – December 22, 2017) - EPA and the Department of Justice announced a Clean Air Act (CAA) settlement with Sid Richardson Carbon and Energy Company that will significantly reduce air pollution from three carbon black manufacturing plants in Louisiana and Texas. The Louisiana Department of Environmental Quality (LDEQ) and Texas Commission on Environmental Quality (TCEQ) participated in the settlement.
Carbon black is a fine carbonaceous powder used as a structural support medium in tires and as a pigment in a variety of products such as plastic, rubber, inkjet toner, and cosmetics. Because the oil used as the carbon black feed is low value high sulfur oil, the manufacturing process creates large amounts of sulfur dioxide, and significant amounts of nitrogen oxide and particulate matter.
- Injunctive Relief
- Pollutant Reductions
- Health Effects and Environmental Benefits
- Environmental Mitigation Projects
- Civil Penalty
- Comment Period
Overview of Company
Sid Richardson owns and operates three carbon black manufacturing plants in Addis, Louisiana, Big Spring and Borger, Texas, and is headquartered in Texas. Sid Richardson is the largest carbon black manufacturer in the United States.
The EPA initiated investigation of the carbon black manufacturing sector in 2007, and of Sid Richardson in 2009. Based upon Sid Richardson’s response to the EPA’s CAA Section 114 information requests and other information obtained during its investigation, the EPA concluded that modifications were performed at its plants that violated the Prevention of Significant Deterioration (PSD) provisions of the CAA.
The consent decree secures injunctive relief from all of Sid Richardson’s carbon black manufacturing facilities in the United States. Compliance with the settlement will reduce sulfur dioxide (SO2) and oxides of nitrogen (NOx) by approximately 11,182 tons per year from 2015 levels. Particulate matter (PM) emissions will also be reduced. The EPA estimates that the cost of the injunctive relief will be over $100 million.
The settlement requires:
- Installation and operation of selective catalytic reduction and compliance with enforceable 7-day and 365-day rolling average emissions limits for NOx at each of its facilities in Addis, Louisiana, Big Spring (incinerator) and Borger, Texas (common boiler stack);
- Installation and operation of dry or wet flue gas desulfurization and compliance with enforceable 7-day and 365-day rolling average emissions limits for SO2 and enforceable 3-hour average emissions limits for PM at its facilities in Addis, Louisiana and Borger, Texas (common boiler stack);
- Compliance with enforceable permit limits of no more than 2.8 percent sulfur content feed, on an annual average basis, by June 30, 2019, at its Big Spring, Texas, facility;
- Optimization and maintenance of existing control devices on other PM emissions points (e.g., baghouses, reactors, various vents and filters) at all three of its facilities;
- Compliance with a fugitive emissions best management practices control plan at all three of its facilities;
- Operation of an early warning PM detection system, that signals when there has been a non-nominal release of PM, at all three of its facilities;
- Installation and operation of NOx continuous emissions monitors at all of its facilities and SO2 continuous emissions monitors at its facilities in Addis, Louisiana and Borger, Texas;
- Cessation of operation of flares at all of its facilities and operation of other technologies for compliance with the carbon black Maximum Achievable Control Technology standard; and
- A thorough mechanical and structural “integrity assessment” of the Borger facility, to find, fix and replace tail gas release points for compliance with the carbon black Maximum Achievable Control Technology standard.
As compared to Sid Richardson’s 2015 emissions, EPA expects the following emission reductions to result from this settlement:
- SO2 about 10,198 tons per year
- NOx about 984 tons per year
Health Effects and Environmental Benefits
The pollutants reduced under this settlement have numerous adverse environmental and health effects. Sulfur dioxides and nitrogen oxides can be converted to fine particulate matter once in the air. Fine particulates can be breathed in and lodged deep in the lungs, leading to a variety of health problems and even premature death. Other health and environmental impacts from the pollutants addressed in this settlement include the following:
Sulfur Dioxide – High concentrations of SO2 affect breathing and may aggravate existing respiratory and cardiovascular disease. Sensitive populations include asthmatics, individuals with bronchitis or emphysema, children, and the elderly. Sulfur dioxide is also a primary contributor to acid deposition, or acid rain.
Particulate Matter – Short term exposure to particulate matter can aggravate lung disease, cause asthma attacks and acute bronchitis, may increase susceptibility to respiratory infections and has been linked to heart attacks.
Nitrogen Oxides – Nitrogen oxides can cause ground-level ozone, acid rain, particulate matter, global warming, water quality deterioration, and visual impairment. Nitrogen oxides play a major role, along with volatile organic chemicals, in the atmospheric reactions that produce ozone. Children, people with lung diseases such as asthma, and people who work or exercise outside are susceptible to adverse effects such as damage to lung tissue and reduction in lung function.
Environmental Mitigation Projects
The proposed consent decree requires Sid Richardson to spend $490,000 on projects to reduce PM emissions, such as installation of a new vacuum system with a high efficiency cartridge filter.
Sid Richardson will pay a total of $999,000 in civil penalties.
The proposed settlement, lodged in the U.S. District Court for the Western District of Louisiana, is subject to a 45-day public comment period and final court approval. Information on submitting comments is available at the Department of Justice website.
Christopher Williams (technical)
Kellie Ortega (legal)
Air Enforcement Division
U. S. Environmental Protection Agency
1200 Pennsylvania Ave, NW, MC 2242A
Washington, DC 20460 mail or 20004 courier